MULTIQUIP DCA-40SSI Especificaciones

© COPYRIGHT 2001, MULTIQUIP INC.PARTS AND OPERATION MANUALMULTIQUIP INC... PARTS DEPARTMENT:18910 WILMINGTON AVE. 800-427-1244CARSON, CALIFORNIA 907

PAGE 10 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)To reduce the possibility of an accidentwhile transporting the generator on p

PAGE 100 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — FLYWHEEL HOUSING ASSY.FLYWHEEL HOUSING ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 101ISUZU 4BD1 — FLYWHEEL HOUSING ASSY.FLYWHEEL HOUSING ASSY.NO. PART NO. PART

PAGE 102 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — OIL PAN ASSY.OIL PAN ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 103ISUZU 4BD1 — OIL PAN ASSY.OIL PAN ASSY.NO PART NO PART NAME QTY. REMARKS1

PAGE 104 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — OIL PAN ASSY.OIL PAN ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 105ISUZU 4BD1 — OIL PAN ASSY.OIL PAN ASSY.NO PART NO PART NAME QTY. REMARKS1

PAGE 106 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — CRANKSHAFT. PISTON, FLYWHEEL ASSY.CRANKSHAFT, PISTON, FLYWHEE

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 107ISUZU 4BD1 — CRANKSHAFT. PISTON, FLYWHEEL ASSY.CRANKSHAFT, PISTON, FLYWHEE

PAGE 108 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — CAMSHAFT, IDLE GEAR, ROCKER ASSY.CAMSHAFT, IDLE GEAR, ROCKER A

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 109ISUZU 4BD1 — CAMSHAFT, IDLE GEAR, ROCKER ASSY.CAMSHAFT, IDLE GEAR, ROCKER A

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 11Explanation of Chart:This section is to provide the user with trailer service

PAGE 110 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — OIL AND FUEL FILTER ASSY.OIL AND FUEL FILTER ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 111ISUZU 4BD1 — OIL AND FUEL FILTER ASSY.OIL AND FUEL FILTER ASSY.NO. PART NO

PAGE 112 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — OIL PIPING ASSY.OIL PIPING ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 113ISUZU 4BD1 — OIL PIPING ASSY.OIL PIPING ASSY.NO. PART NO. PART NAME QTY. RE

PAGE 114 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — COOLING ASSY.COOLING ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 115ISUZU 4BD1 — COOLING ASSY.COOLING ASSY.NO. PART NO. PART NAME QTY. REMARKS

PAGE 116 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)INTAKE AND EXHAUST ASSY.ISUZU 4BD1 — INTAKE AND EXHAUST ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 117ISUZU 4BD1 — INTAKE AND EXHAUST ASSY.INTAKE AND EXHAUST ASSY.NO. PART NO. P

PAGE 118 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — FUEL INJECTION ASSY.FUEL INJECTION ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 119ISUZU 4BD1 — FUEL INJECTION ASSY.FUEL INJECTION ASSY.NO. PART NO. PART NAM

PAGE 12 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)snoitacificepS.1elbaTLEDOM NOITACILPPA LEUFLLECEKARBMETSYSRWVG EMARFHTGNELEMA

PAGE 120 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — ENGINE FOOT ASSY.ENGINE FOOT ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 121ISUZU 4BD1 — ENGINE FOOT ASSY.ENGINE FOOT ASSY.NO. PART NO. PART NAME QTY.

PAGE 122 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — ENGINE CONTROL ASSY.ENGINE CONTROL ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 123ISUZU 4BD1 — ENGINE CONTROL ASSY.ENGINE CONTROL ASSY.NO. PART NO. PART NA

PAGE 124 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — INJECTION PUMP ASSY.INJECTION PUMP ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 125ISUZU 4BD1 — INJECTION PUMP ASSY.INJECTION PUMP ASSY.NO. PART NO. PART NAME

PAGE 126 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — ELECTRICAL COMPONENTS ASSY.ELECTRICAL COMPONENTS ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 127ISUZU 4BD1 — ELECTRICAL COMPONENTS ASSY.ELECTRICAL COMPONENTS ASSY.NO. PART

PAGE 128 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — FEED PUMP COMP. ASSY.FEED PUMP COMP. ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 129ISUZU 4BD1 — FEED PUMP COMP. ASSY.FEED PUMP COMP. ASSY.NO. PART NO. PART NA

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 13)t'noC(snoitacificepS.1elbaTLEDOM RELPUOC SERIT SLEEHW ELXA SBUH NOISNEP

PAGE 130 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — NOZZLE ASSY.NOZZLE ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 131ISUZU 4BD1 — NOZZLE ASSY.NOZZLE ASSY.NO. PART NO. PART NAME QTY. REMARKS1 5

PAGE 132 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — OIL FILTER ASSY.OIL FILTER ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 133ISUZU 4BD1 — OIL FILTER ASSY.OIL FILTER ASSY.NO. PART NO. PART NAME QTY. RE

PAGE 134 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — FUEL FILTER ASSY.FUEL FILTER ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 135ISUZU 4BD1 — FUEL FILTER ASSY.FUEL FILTER ASSY.NO. PART NO. PART NAME QTY.

PAGE 136 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — ENGINE ACCESSORIESENGINE ACCESSORIES

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 137ISUZU 4BD1 — ENGINE ACCESSORIESENGINE ACCESSORIESNO. PART NO. PART NAME QTY

PAGE 138 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)PAYMENT TERMSTerms of payment for parts are net 10 days.FREIGHT POLICYAll pa

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 139NOTE PAGE

PAGE 14 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI —TRAILER SAFETY GUIDELINESBrakesIf your trailer has a braking sys

© COPYRIGHT 2001, MULTIQUIP INC.PARTS AND OPERATION MANUALMULTIQUIP INC... PARTS DEPARTMENT:18910 WILMINGTON AVE. 800-427-1244CARSON, CALIFORNIA 907

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 15DCA-40SSI — TRAILER SAFETY GUIDELINESHydraulic/Air/Surge BrakesHydraulic br

PAGE 16 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)Tires/Wheels/Lug NutsTires and wheels are a very important and criticalcompon

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 17stnemeriuqeReuqroTnoisnepsuS.3elbaTmetI ).sbL-.tF(euqroTTLOB-U"8/353-XAM

PAGE 18 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)NOTE:LIGHTS ARE ORIENTED FROM THE DRIVER’S SEATDCA-40SSI —TRAILER-WIRING DI

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 19gnitoohselbuorTekarBcirtcelE.5elbaTmotpmyS esuaCelbissoP noituloSsekarBtnetti

PAGE 2 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)

PAGE 20 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)gnitoohselbuorTekarBciluardyH.6elbaTmotpmyS esuaCelbissoP noituloSsekarBoN?de

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 21DCA-40SSI — GENERATOR DECALSThe DCA-40SSI generator is equipped with a numb

PAGE 22 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — GENERATOR DECALS

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 23DCA-40SSI — SPECIFICATIONSsnoitacificepS.7elbaTsnoitacificepSrotareneGledoM

PAGE 24 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — GENERAL INFORMATIONDCA-40SSI FAMILIARIZATIONGeneratorThe MQ P

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 25DCA-40SSI — MAJOR COMPONENTS Figure 6. Major Components

PAGE 26 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — DIMENSIONS (SIDE AND BACK) Figure 7a. Dimensions

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 27DCA-40SSI — DIMENSIONS (TOP AND FRONT) Figure 7b. Dimensions

PAGE 28 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — CONTROL PANEL Figure 8. Control Panel

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 29DCA-40SSI — CONTROL PANELThe definitions below describe the controls and fun

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 3HERE'S HOW TO GET HELPPLEASE HAVE THE MODEL AND SERIAL NUMBERON-HAND WHEN

PAGE 30 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — ENGINE OPERATING PANEL Figure 9. Engine Operating Panel

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 31The definitions below describe the controls and functions ofthe DCA-40SSI &q

PAGE 32 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — OUTPUT TERMINAL PANELOutput Terminal PanelThe output control pane

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 33DCA-40SSI — OUTPUT TERMINAL VOLTAGE SELECTIONDCA-40SSILegs O and Ground areco

PAGE 34 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)elbaliavAsegatloV.8elbaTesahPeerhT)elbahctiwS(TLOV802TLOV022TLOV042TLOV614TLO

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 35esUelcatpeceR.01elbaTesUnirewoPelcatpeceRrewoPelbaliavAV084/042esahP-3V021/04

PAGE 36 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)240/120V Hard Wire HookupWith the voltage selector set and locked at ‘single

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 37Voltage Selector Switch- 3 Phase 480/277V PositionThe following are additiona

PAGE 38 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)Voltage Selector Switch- 3 Phase 240/139V PositionThe following are additiona

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 39Voltage Selector Switch- Single Phase 240/120VPositionThe following are addi

PAGE 4 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)TABLE OF CONTENTSHere's How To Get Help ...

PAGE 40 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)Outdoor InstallationInstall the generator in a location where it will not be

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 41Figure 31. Typical Generator Grounding ApplicationDCA-40SSI — INSTALLATION

PAGE 42 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)General Inspection Prior to OperationThe DCA-40SSI generator has been thorou

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 43Lubrication OilFill the engine crankcase with lubricating oil through the fil

PAGE 44 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — PRE-SETUPDay-to-day addition of coolant is done from the reserve

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 45DCA-40SSI — PRE-SETUPBattery Cable InstallationALWAYS be sure the battery ca

PAGE 46 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — LOAD APPLICATIONSingle Phase LoadAlways be sure to check the name

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 47WARNING:WARNING:WARNING:WARNING:WARNING:Before StartingEngine1. Check the lub

PAGE 48 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)9. The generator's frequency meter (Figure 43) displaysthe 60 cycle outp

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 49A040607520Figure 46. Ammeter (No Load)11. The ammeter (Figure 46) will indica

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 5PARTS ORDERING PROCEDURESGet special freight allowanceswhen you order 10 or mo

PAGE 50 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)1. To stop the engine in the event of an emergency, switchthe MAIN, GFCI and

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 51NOTE PAGE

PAGE 52 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — MAINTENANCEGeneral InspectionPrior to each use, the generator sh

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 53DCA-40SSI — MAINTENANCECAUTION :CAUTION :CAUTION :CAUTION :CAUTION :Allow en

PAGE 54 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — MAINTENANCEFigure 55. Valve AdjustmentValve Clearance Check1. I

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 55Generator StorageFor storage of the generator for over 30 days, the following

PAGE 56 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — ENGINE WIRING DIAGRAM

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 57DCA-40SSI — ENGINE WIRING DIAGRAM

PAGE 58 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — GENERATOR WIRING DIAGRAM

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 59NOTE PAGE

PAGE 6 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)RULES FOR SAFE OPERATION NEVER touch the hot exhaustmanifold, muffler or cylin

PAGE 60 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI — TROUBLESHOOTING (ENGINE)Practically all breakdowns can be preven

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 61DCA-40SSI — TROUBLESHOOTING (ENGINE))DEUNITNOC(GNITOOHSELBUORTENIGNE.71ELBAT

PAGE 62 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)GNITOOHSELBUORTROTARENEG.81ELBATMOTPMYS MELBORPELBISSOP NOITULOStuptuOegatloV

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 63NOTE PAGE

PAGE 64 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)How to read the marks and remarks used in this partsbook.Items Found In the “

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 65DCA-40SSI W/ISUZU 4BG1 DIESEL ENGINE 1 TO 3 UNITSDCA-40SSI — SUGGESTED SPARE

PAGE 66 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- GENERATOR ASSY.GENERATOR ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 67NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- GENERATOR ASSY.GENERATOR ASSY.1 8

PAGE 68 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- CONTROL BOX ASSY.CONTROL BOX ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 69NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- CONTROL BOX ASSY.CONTROL BOX ASSY

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 7RULES FOR SAFE OPERATIONCAUTIONCAUTIONCAUTIONCAUTIONCAUTION: Backfeed to a uti

PAGE 70 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI ENGINE AND RADIATOR ASSY.ENGINE AND RADIATOR ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 71DCA-40SSI ENGINE AND RADIATOR ASSY.NO. PART NO. ITEM QTY. REMARKSENGINE AND

PAGE 72 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI ENGINE AND RADIATOR ASSY.ENGINE AND RADIATOR ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 73DCA-40SSI ENGINE AND RADIATOR ASSY.NO. PART NO. ITEM QTY. REMARKSENGINE AND

PAGE 74 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ENGINE OPERATING PANEL ASSY.DCA-40SSI --- ENGINE OPERATING PANEL ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 75ENGINE OPERATING PANEL ASSY.DCA-40SSI --- ENGINE OPERATING PANEL ASSY.NO. PAR

PAGE 76 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ENGINE OPERATING PANEL ASSY.DCA-40SSI --- ENGINE OPERATING PANEL ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 77ENGINE OPERATING PANEL ASSY.DCA-40SSI --- ENGINE OPERATING PANEL ASSY.NO. PAR

PAGE 78 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- BATTERY ASSY.BATTERY ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 79NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- BATTERY ASSY.BATTERY ASSY.1 01684

PAGE 8 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)RULES FOR SAFE OPERATION NEVER Run engine without air filter. Severe engineda

PAGE 80 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- MUFFLER ASSY.MUFFLER ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 81NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- MUFFLER ASSY.MUFFLER ASSY.1 33423

PAGE 82 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- FUEL TANK ASSY.FUEL TANK ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 83NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- FUEL TANK ASSY.FUEL TANK ASSY.1 3

PAGE 84 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ENCLOSURE ASSY.DCA-40SSI --- ENCLOSURE ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 85NO. PART NO. ITEM QTY. REMARKSENCLOSURE ASSY.DCA-40SSI --- ENCLOSURE ASSY.1 8

PAGE 86 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ENCLOSURE ASSY.DCA-40SSI --- ENCLOSURE ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 87ENCLOSURE ASSY.DCA-40SSI --- ENCLOSURE ASSY.NO. PART NO. ITEM QTY. REMARKS952

PAGE 88 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- ENCLOSURE ASSY.ENCLOSURE ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 89NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- ENCLOSURE ASSY.ENCLOSURE ASSY.55

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 9Transporting Always shutdown engine before transporting. Tighten fuel tank cap

PAGE 90 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)DCA-40SSI --- DECALSDECAL ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 91NO. PART NO. ITEM QTY. REMARKSDCA-40SSI --- DECALSDECAL ASSY.1 M1550000204 DE

PAGE 92 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)CYLINDER HEAD COVER ASSY.ISUZU 4BD1 — CYLINDER HEAD COVER ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 93ISUZU 4BD1 — CYLINDER HEAD COVER ASSY.EA1013CYLINDER HEAD COVER ASSY.NO PART

PAGE 94 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — CYLINDER BLOCK ASSY.CYLINDER BLOCK ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 95ISUZU 4BD1 — CYLINDER BLOCK ASSY.CYLINDER BLOCK ASSY.NO PART NO PART NAME Q

PAGE 96 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — CYLINDER BLOCK ASSY.CYLINDER BLOCK ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 97ISUZU 4BD1 — CYLINDER BLOCK ASSY.70 0500408160 BOLT 171 9091606080 PLAIN WASH

PAGE 98 — DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01)ISUZU 4BD1 — TIMING GEAR ASSY.TIMING GEAR ASSY.

DCA-40SSI — PARTS AND OPERATION MANUAL— FINAL COPY (07/10/01) — PAGE 99ISUZU 4BD1 — TIMING GEAR ASSY.TIMING GEAR ASSY.NO. PART NO. PART NAME QTY. RE